产品：PVH131C-RF-13S-11-CM7-31-115
产地：美国
类型：柱塞泵
性能：抗耐磨
驱动：电动
材质：铸铁
质保：一年
包装： 木箱 泡沫
威格士柱塞泵常见故障处理
1.柱塞泵输出流量不足或不输出油液
(1)吸入量不足。原因是吸油管路上的阻力过大或补油量不足。如泵的转速过大，油箱中液面过低，进油管漏气，滤油器堵塞等。
(2)泄漏量过大。原因是泵的间隙过大，密封不良造成。如配油盘被金属碎片、铁屑等划伤，端面漏油;变量机构中的单向阀密封面配合不好，泵体和配油盘的支承面有砂眼或研痕等。可以通过检查泵体内液压油中混杂的异物判别泵被损坏的部位。
(3)倾斜盘倾角太小，泵的排量少，这需要调节变量活塞，增加斜盘倾角。
2.中位时排油量不为零 变量式轴向柱塞泵的斜盘倾角为零时称为中位，此时泵的输出流量应为零。但有时会出现中位偏离调整机构中点的现象，在中点时仍有流量输出。其原因是控制器的位置偏离、松动或损伤，需要重新调零、紧固或更换。泵的角度维持力不够、倾斜角耳轴磨损也会产生这种现象。
3.输出流量波动 输出流量波动与很多因素有关。对变量泵可以认为是变量机构的控制不佳造成，如异物进入变量机构，在控制活塞上划出阶痕、磨痕、伤痕等，造成控制活塞运动不稳定。由于放大器能量不足或零件损坏、含有弹簧的控制活塞的阻尼器效能差，都会造成控制活塞运动不稳定。流量不稳定又往往伴随着压力波动。这类故障一般要拆开液压泵，更换受损零部件，加大阻尼，提高弹簧刚度和控制压力等。
4.输出压力异常 泵的输出压力是由负载决定的，与输入转矩近似成正比。输出压力异常有两种故障。
(1)输出压力过低 当泵在自吸状态下，若进油管路漏气或系统中液压缸、单向阀、换向阀等有较大的泄漏，均会使压力升不上去。这需要找出漏气处，紧固、更换密封件，即可提高压力。溢流阀有故障或调整压力低，系统压力也上不去，应重新调整压力或检修溢流阀。如果液压泵的缸体与配流盘产生偏差造成大量泄漏，严重时，缸体可能破裂，则应重新研磨配合面或更换液压泵。
(2)输出压力过高 若回路负载持续上升，泵的压力也持续上升，当属正常。若负载一定，泵的压力超过负载所需压力值，则应检查泵以外的液压元件，如方向阀、压力阀、传动装置和回油管道。若Z大压力过高，应调整溢流阀。
5.振动和噪声 振动和噪声是同时出现的。它们不仅对机器的操作者造成危害，也对环境造成污染。
(1)机械振动和噪声 如泵轴和电机轴不同心或顶死，旋转轴的轴承、联轴节损伤，弹性垫破损和装配螺栓松动均会产生噪声。对于高速运转或传输大能量的泵，要定期检查，记录各部件的振幅、频率和噪声。如泵的转动频率与压力阀的固有频率相同时，将会引起共振，可改变泵的转速以消除共振。
(2)管道内液流产生的噪声 进油管道太细、进油滤油器通流能力过小或堵塞、进油管吸入空气、油液豁度过高、油面过低吸油不足和高压管道中产生液击等，均会产生噪声。因此，必须正确设计油箱，正确选择滤油器、油管和方向阀。
6.威格士柱塞泵过热 液压泵过度发热有两个原因，一是机械摩擦生热。由于运动表面处于干摩擦或半干摩擦状态，运动部件相互摩擦生热。二是液体摩擦生热。高压油通过各种缝隙泄漏到低压腔，大量的液压能损失转为热能。所以正确选择运动部件之间的间隙、油箱容积和冷却器，可以杜绝泵的过度发热和油温过高的现象。另外，回油过滤器堵塞造成回油背压过高，也会引起油温过高和泵体过热。
7.漏油 柱塞泵漏油主要有以下原因:(1)主轴油封损坏或轴有缺陷、划痕;(2)内部泄漏过大，造成油封处压力增大，而将油封损伤或冲出;(3)泄油管过细过长，使密封处漏油;(4)泵的外接油管松动，管接头损伤，密封垫老化或产生裂纹;(5)变量调节机构螺栓松动，密封破损;(6)铸铁泵壳有砂眼或焊接不良。
PVE12R-B2-MS-10-C20VPC22-P-13-271
PVE19-B2L-A11-STS2F-41-C21VPC24B-13
PVE19-B2L-B26-STS2F-41-C21VP11B-13
PVE19-B2L-B26-STS9F-41-C21VPC30P-13-338
PVE19-B2L-STE9F-41-C16VPC24P-13
PVE19-B2L-STE9F-41-C21VPD41B-13-255
PVE19-B2L-STS2F-41-C17-12
PVE19-B2L-STS2F-41-C21VP14P-13-365
PVE19-B2L-STS5F-41-C16-12-302
PVE19-B2L-STS9F-41-C21VP11B-13
PVE19-B2R-A9-STS1F-41-C21-12
PVE19-B2R-B26-STS1F-41-C21VPC30P-13-338
PVE19-B2R-B26-STS33F-41-C12VP11B-13
PVE19-B2R-B26-STS9F-41-C21-12
PVE19-B2R-SFE13F-41-C14VP11P-13-253
PVE19-B2R-STE9F-41-C21VP11P-D-13
PVE19-B2R-STS16F-41-C14-12-061
PVE19-B2R-STS1F-41-C21-12
PVE19-B2R-STS28F-41-C12VP11B-13-237
PVE19-B2R-STS28N-41-C21VP11B-13-121
PVE19-B2R-STS9F-41-C16-12-223
PVE19-B2R-STS9F-41-C17VPC14P-13-356
PVE19-B2R-STS9F-41-C21-12
PVE19-B2R-STS9F-41-C21VPC26B-13-387
PVE19G-B2R-STS2N-41-C16VPC19B-13-305
PVE21-B2L-MFS2F-41-C21VP15P-13-393
PVE21-B2L-SFE9F-41-UV-20-293
PVE21-B2L-STS13F-41-C20VPC17P-13-269
PVE21-B2L-STS31F-41-C19VP14P-13-248
PVE21-B2L-STS9F-41-C20VPC24B-13-390
PVE21-B2R-A9-MFS2F-41-C21VP24P-13-333
PVE21-B2R-B26-STS2F-41-C19-12
PVE21-B2R-MFE2AF-41-C16VPC21P-13-307
PVE21-B2R-MFE2AF-41-C20VPC30P-13-400
PVE21-B2R-SFE2F-41-C19VPC24B-13-213
PVE21-B2R-STE2F-41-C21VPC24B-D-13-268
PVE21-B2R-STE9F-41-C20VPC24P-13-295
PVE21-B2R-STS9F-41-C19VP11B-13
PVE19/21 RH&LH
PVE35-QR122C21V172
PVE35-QIR-A13-?22-C20-21
PVE47R-A13-22-CM7-21
PVE47R-1-22-C14-21
PVE000R000020B351600A000 0000
PVE012L05AUB0A2100000100 100CD0A
PVE012R01AUB0B2111000100 100CD0A
PVE012R05AUB0B211100A100 100CD0
PVE012L071204RE11016
PVE12R QB1 ES 10 C21 10
PVE12R QB1 ES 10 CG 10
PVE12R QB2 ES 10 C21 10
PVE19/21 B2
PVE190L01AA10B2111000100 1AGCD0A
PVE190L08AA10A21000001AE 100CD0A
PVE190L08AA10H1811000600 100CD0A
PVE190L08AAA0B2111000100 100CD0A
PVE190R02AA10B2111000100 100CD0A
PVE190R02AA10B2111000600 1AGCD0A
PVE190R05AA10A2100000100 100CD0A
PVE190R05AC10B211100A1AA 100CD0A
PVE1919L Q1830 2 30 CVP 12 CVP
PVE19AL02AA10B2111000100 1AGCD0
PVE19AL02AA10B211100A100 100CD0A
PVE19AL05AA10B211100A100 100CD0A
PVE19AL08AA10A2100000100 100CD0A
PVE19AL08AA10B211100A100 100CD0A
PVE19AL08AA10H211100A100 1AGCD0
PVE19AR01AA10A140000E100 100CD0A
PVE19AR02AA10A2100000100 100CD0A
PVE19AR02AA10A21000001AA 1APCD0A
PVE19AR02AA10A2100000200 100CD0
PVE19AR02AA10B211100A100 100CDOA
PVE19AR02AC10A21000001AA 1APCD0A
PVE19AR05AA10A400000F100 100CD0
PVE19AR05AA10B211100A100 100CD0A
PVE19AR08AA10A2100000100 100CD0
PVE19AR08AA10B211100A100 100CD0A
PVE19AR08AA10B33110001AK 100CD0
PVE19L/PVE19L
PVE19R/PVE19R
PVE19LW-Q1830-1-30-CVP-12
PVE21 B2L STE9F 41 C19VP 11B 13
PVE21 B2L STS2F 41 C19 1 2
PVE21 B2L STS2F 41 C19VP 11B 13
PVE21 B2R STE2F 41 C19VP 11P 13
PVE21 B2R STE9F 41 C19VP11P13
PVE21 B2R STS1F41C19VP11B13
PVE21 B2R STS2F 41C1912
PVE21 B2R STS2F41C19VP11P13
PVE21 B2R STS9F41C1912
PVE210L08AA10B1811000100100CD0A
PVE210L08AA10B1824000100100CDEA
PVE210L08AA10B182400A1AG100CD0A
PVE21AL21AA10B1811000100100CDE
PVE21AR02AA10A1800000100100CD0
PVE21AR05AA10B191100A100100CD0A
PVE21AR08AA10B181100A100100CD0
PVE21AR08AA10B211100A1AG100CD0
PVE21 B2L STS9F41C19VP11B13
PVM131ER10GS02AAB28110000A0A
PVM131ER09GS02AAE00200000A0A
PVM131ER09GS02AAC23200000A0A
PVM131ER10GS02AAC28200000A0A
PVM131ER13GS02AAA28000000A0A
PVM131ER19HS02AAC28200000A0A
PVM131ER13GS02AAF0020000EA0A
PVM106ER11GS02AAF00200000A0A
PVM106ER09GS02AAA23000000A0A
PVM098ER10GS04AAB28110000A0A
PVM098ER19FS04AAA28000000A0A
PVM098ER09GS02AAA07000000A0A
PVM098ER09GS02AAE00200000A0A
PVM098ER09ES02AAC23110000A0A
PVM098ER10GS02AAB28110000A0A
PVM098ER09GS02AAC28200000A0A
PVM098ER10GS02AAE0020000EA0A
PVM098ER09GS02AAA28000000A0A
PVM098ER09GS02ASA28000000A0A
PVM098ER11GS02AAA28000000A0A
PVM098ER10GS02AAA2800000EA0A
PVM098ER09GS04AAA28000000A0A
PVM098ER09GS04AAC28200000A0A
PVM098ER09GS02AAC28110000A0A
PVM098ER11ES02AAC28200000A0A
PVM081ER09GS02AAC2320000000A
PVM081ER09GS02AAA23000000A0A
PVM081ER09ES02AAA23000000A0A
PVM074ER09GS02AAE0020000AA0A
PVM074ER09GS04AAC28200000A0A
PVM074ER09ES02AAC23200000A0A
PVM074ER09GS02AAC28110000A0A
PVM074ER19FS04AAA28000000A0A
PVM074ER09GS02AAA28000000A0A
PVM074ER09GS02AAA07000000A0A
PVM074ER19FS04AUF0020000000A
PVM074ER10ES02AAB28110000A0A
PVM074ER09GS02AAC28200000A0A
PVM063ER09ES02AAA21000000A0A
PVM063ER09EE02AAA21000000A0A
PVM063ER11GS02AAA23000000A0A
PVM063ER09EE01AAA07000000A0A
PVM057ER09ES02AAA28000000A0A
PVM057ER09GS02AAA07000000A0A
PVM057ER09GS02AAC28200000A0A
PVM057ER09GS02AAA0700000AA0A
PVM057ER09GS02AAB2811000AA0A
PVM057ER09EE02AAB10110000A0A
PVM057ER09GS02AAC28110000A0A
PVM057ER09GS02AAC2820000CA0A
PVM057ER09GS02AAA28000000A0A
PVM050EL07CS01AAB2320000AA0A
PVM050ER05CS02AAC21110000A0A
PVM045ER06CS02AAA28000000A0A
PVM045ER05CS02AAA07000000A0A
PVM045ER05CS02AAC28110000A0A
PVM045ER05CS0200C28110000A0A
PVM045ER05CE01AAA28000000A0A
PVM045ER05CS05AAB28110000A0A
PVM045ER05CE04AAA28000000A0A
PVM045ER05CS02AAC28200000A0A
PVM045ER07DE05AAA23000000A0A
PVM045ER17DS05AAA0700000AA0A
PVM045ER17DS04AAA28000000A0A
PVM045ER07CS02AAC28110000A0A
PVM045ER05CE01AAB28110000A0A
PVM045ER06CS05AAC28200000A0A
PVM045ER06CS02AAC2320000AA0A
PVM045ER05CS02AAA28000000A0A
PVM045ER05CS02AAB21110000A0A
PVM045ER05CS01AAA28000000A0A
PVM045ER06CS02AAB28110000A0A
PVM045ER07CS02AAC28200000A0A
PVM045ER17DS05AAB2311000CA0A
PVM045ER06CS02AAC28110000A0A
PVM045ER06CS02AAB21110000A0A
PVM045ER05CS01AAA2800000AA0A
PVM045ER05CS0200C2320000CA0A
PVM045ER05CE05AAA07000000A0A
PVM045ER06CS02AAC2811000DA0A
PVM045ER08CS02AAC28110000A0A
PVM045ER05CE02AAA07000000A0A
PVM020ER05CS01AAB23110000A0A
PVM020ER02AS02AAC23240000A0A
PVM020ER07CS02AAC2320000AA0A
PVM020ER02AE01AAA23000000A0A
PVM018ER02AE01AAA28000000A0A
PVM018ER01AS05AAB28110000A0A
PVM018ER01AE01AAB28110000A0A
PVM018ER01AS02AAA28000000A0A
PVM018ER02AS01AAC28110000A0A
PVM018ER01AS02AAC23110000A0A
PVM018ER07CS01AAB23200000A0A
PVM018ER01AS01AAB23110000A0A
PVM018ER03AE01AAB28200000A0A
PVM018ER05CS02AAC28110000A0A
PVM018ER02AS05AAC28200000A0A
PVM018ER06CS01AAA2800000AA0A
PVM018ER02AE01AAB25200000A0A
PVM018ER03AE05AAA07000000A0A
PVM018ER01AE01AAA28000000A0A
PVM018ER02AS02AAA28000000A0A
3525VQ-25A12-1CC-10R
3525VQ-25A14-1CC-10R
3525VQ-25A17-1CC-10R
3525VQ-25A19-1CC-10R
3525VQ-30A10-1CC-10R
3525VQ-30A12-1CC-10R
3525VQ-30A14-1CC-10R
3525VQ-30A17-1CC-10R
3525VQ-30A19-1CC-10R
3525VQ-35A10-1CC-10R
3525VQ-35A12-1CC-10R
3525VQ-35A14-1CC-10R
3525VQ-35A17-1CC-10R
3525VQ-35A19-1CC-10R
3525VQ-38A10-1CC-10R
3525VQ-38A12-1CC-10R
3525VQ-38A14-1CC-10R
3525VQ-38A17-1CC-10R
3525VQ-38A19-1CC-10R
4520VQ
4520VQ-42A5-1AA-10R
4520VQ-45A5-1AA-10R
4520VQ-50A5-1AA-10R
4520VQ-60A5-1AA-10R
4520VQ-42A8-1AA-10R
4520VQ-45A8-1AA-10R
4520VQ-50A8-1AA-10R
4520VQ-60A8-1AA-10R
4520VQ-42A9-1AA-10R
4520VQ-45A9-1AA-10R
4520VQ-50A9-1AA-10R
4520VQ-60A9-1AA-10R
4520VQ-42A11-1AA-10R
4520VQ-45A11-1AA-10R
4520VQ-50A11-1AA-10R
4520VQ-60A11-1AA-10R
4520VQ-42A12-1AA-10R
4520VQ-45A12-1AA-10R
4520VQ-50A12-1AA-10R
4520VQ-60A12-1AA-10R
4520VQ-42A14-1AA-10R
4520VQ-45A14-1AA-10R
4520VQ-50A14-1AA-10R
4520VQ-60A14-1AA-10R
4525VQ-42A10-1AA-10R
4525VQ-45A10-1AA-10R
4525VQ-50A10-1AA-10R
4525VQ-60A10-1AA-10R
4525VQ-42A12-1AA-10R
4525VQ-45A12-1AA-10R
4525VQ-50A12-1AA-10R
4525VQ-60A12-1AA-10R
4525VQ-42A14-1AA-10R
4525VQ-45A14-1AA-10R
4525VQ-50A14-1AA-10R
4525VQ-60A14-1AA-10R
4525VQ-42A17-1AA-10R
4525VQ-45A17-1AA-10R
4525VQ-50A17-1AA-10R
4525VQ-60A17-1AA-10R
4525VQ-42A19-1AA-10R
4525VQ-45A19-1AA-10R
4525VQ-50A19-1AA-10R
4525VQ-60A19-1AA-10R
4525VQ-45A21-1AA-10R
4525VQ-50A21-1AA-10R
4525VQ-60A21-1AA-10R
4535VQ
4535VQ-42A25-1AA-10R
4535VQ-45A25-1AA-10R
4535VQ-50A25-1AA-10R
4535VQ-60A25-1AA-10R
4535VQ-42A30-1AA-10R
4535VQ-45A30-1AA-10R
4535VQ-50A30-1AA-10R
4535VQ-60A30-1AA-10R
4535VQ-42A35-1AA-10R
4535VQ-45A35-1AA-10R
4535VQ-50A35-1AA-10R
4535VQ-60A35-1AA-10R
4535VQ-42A38-1AA-10R
4535VQ-45A38-1AA-10R
4535VQ-50A38-1AA-10R
4535VQ-60A38-1AA-10R
4535VQ60A25-1AA-22R
4535VQ60A25-1CC-22R
4525VQ60A12-1AA-22R
4525VQ60A12-1CC-22R
2520VQ17A5-1AA-22R
2520VQ17A5 1AB22R
2520VQ17A8 1AA22R
2520VQ17A8 1CC22L
2520VQ17A8 1CB22R
2520VQ17A11 86DD22R
2520VQ17A11 1DD22R
2520VQ17A14 1AA22R
2520VQ21A5 1AA22R
2520VQ21A5 1CC22R
2520VQ21A8 1CC22R
2520VQ21A8 1DD22R
2520VQ21A11 1AA22R
2520VQ21A12 1AA22R
2520VQ21A12 1BB22R
2520VQ21A14 1AD22R
3520VQ25A5 1CC22R
3520VQ25A8-86CB22R
3520VQ30A5 1DC22R
20VQ5A 1C22R
20VQ8A-1C22L
20VQ8A 151C22R
20VQ11A 1A22R
20VQ11A 1B22R
25VQ10A-1C22R
25VQ12A 1B22R
25VQ14AF-1C22R
25VQ14AM-1D22R
25VQ17A 1A22R
25VQ17A 1B22R
25VQ17A 1C22R
35VQ25A 1A22R
35VQ25A 1B22R
35VQ30A 1C22R
3525VQ35A21-1BA22R
3525VQ38A12-1BB-22R
3525VQ38A14 11AA22R
3525VQ38A17 1AA22R
3525VQ38A17 1BB22R
3525VQ38A21 86BB22R
3525VQ38A21 86CC22R
3525VQQ30A21 1DD20
4520VQ42A5 1CC22R
4520VQ42A11 1AB22R
4520VQ42A12 86DD22R
4520VQ50A5 1CC22R
4520VQ50A8 1CC22R
4520VQ50A11 1AA22R
4520VQ50A11 1CC22R
4520VQ50A12 1AA22R
4520VQ50A14-1AA22L
4520VQ60A5 1CC22R
4520VQ60A8 1AA22R
4520VQ60A8 1CC22R
4520VQ60A11 1AD22R
